Detroit 60 series starting problems.

I have an intermittent issue with a 99 Detroit 60 series in a western star 4964 it Will crank and no start check engine light and stop engine light don’t come on when problem happens but after shaking harness and connections on ecm battery’s and junction box on firewall truck will start and run doesn’t have a specific place that has to be wiggled to get to start but once started truck ...1999 freightliner 12.7 detroit had a problem starting driver pulled the batteries down pretty low and I could smell something electrical burning I installed new batteries truck still would start but w ... having a power problem with a detroit desiel 60 series. check it with a computer .Its not injectors or turbo.2007 Freightliner Columbia Detroit 14L no throttle Discussion in 'Freightliner Forum' started by chr1s427, Feb 4, 2014. Page 1 ... they start getting play in them, when you let off the Accelerator Pedal, even though the pedal physically is back at Zero, internally the position that the ECM is reading is not, causing the hesitation because the ...I have a Freightliner Century with a Detroit 12.7 s60. Recently the truck has become very hard to start and has lost power specially when going up hills. I have checked and cleaned the check valve on the filter and also the check valve behind the cylinder head. But still the same difficulty in starting, I have to use starting fluid all the time.Detroit 60 series hard start in morning Discussion in 'Freightliner Forum' started by rsinghpal, Aug 23, 2023. Aug 23 ... Having a strange problem with my truck and I was hoping someone here would have a clue based on my particular symptoms. I have a 2005 Freightliner with a 14l EGR Detroit 60 Series. For the last several weeks if I turn the ...

Series 60 Low Battery Voltage. To determine if a weak battery is causing starting difficulty, perform the following steps: ‪. Measure the battery voltage; refer to OEM guidelines. If voltage is between 10.5 - 14 volts (21 - 26 volts for a 24 volt system), check the terminals; If voltage is less than 10.5 volts (21 volts for a 24 volt ...Instruction on how to change your pers sensor located below the air compressor on it detroit 60 series 12.7 motorHere is my problem I have a 12.7 detroit 60 series and it seems like it just doesn't have any power. The turbo whistle is very faint. I have a little bit of black smoke out of pipe when i accelerate onto the interstate. I had a brand new crate model put in 2008 and they didnt change the turbo. I believe this is the original turbo.

so my truckhas had an inframe with 15:1 pistons and now I have horrible smoke on startup. Goes away once warm but in cold days it could take 20 mins or longer. Will be going back into it to fix the issue. Would like to know how do I find out which 16.5:1 piston kit would be and if there is one that’s a straight bolt in. It’s a ddec 3 gk motor.5 Apr 2023 ... Dakota shows how to check the ECM or computer of a Detroit series 60 engine and some bonus footage of how to properly take off a driveshaft ...

The values correspond to the following options/information: Detroit 60 Series diesel specs, history, information, and torque curves. The Detroit 60 Series engine platform included an 11.1L, 12.7L, and 14L inline 6 cylinder diesel engine. 60 Series Detroits are widely popular in a number of on-highway and off-highway industries.Start it will run good all day when I stop it and try to start again it will not start shows both timing sensor codes so - Answered by a verified Technician ... Hi clayton I have a 2005 Columbia sleeper with a series 60 Detroit diesel 515 I have a no start problem,changed the starter still wont start it will engage,then solenoid on starter just ...Series 60 Improper Engine Coolant Level To determine if improper engine coolant level is causing high engine coolant temperature, perform the following: ‪ Visually inspect the… Posted in TroubleshootingDec 6, 2013 · Hard start on a series 60. New injectors, head, bullgear, sensors, fuel system. Also tested with known good ECM and program. It was approximately 15C (... Alfa Romeo's Giulia was named Motor Trend magazine's Car of the Year and did not disappoint at this year's Detroit auto show. Watch!...FCAU Alfa Romeo's Giulia was name...

Amedisys perks at work

Series 60 - Section 1.20 One-Piece Piston Assembly and Piston Ring; Series 60 - Section 1.21 Piston and Connecting Rod Assembly; Series 60 - Section 1.17 Ring Gear; Series 60 - Section 1.18 Flywheel Housing; Series 60 - Section 1.14 Crankshaft Vibration Damper; Series 60 - Section 1.15 Crankshaft Pulley; Series 60 - Section 1.16 ...

About Press Copyright Contact us Creators Advertise Developers Terms Privacy Policy & Safety How YouTube works Test new features NFL Sunday Ticket Press Copyright ...Some of the early detroits 60 series had low fuel pressure, also There is a white coupling between the Air compressor and the fuel pump, everytime I replace the fuel pump, we replace that. That could be worn or broke. Ask Your Own Heavy Equipment Question. Yes I put in a new coupler between the air compressor and fuel pump.Series 60 - STARTING DIFFICULTY - ENGINE ROTATES - EXTENDED CRANK TIME. There are no fault codes present and the engine finally starts after an extended crank time. 4.13.1 Fuel Level/Leaks Check…Fixing some stuff on a freightliner.Learn how to fix the ECM problem on your Detroit 60 Series engine with this semi mechanical tutorial video.

3 Most Common Issues with Series 60. 1. Spun Bearings. The Series 60 is no stranger to bearings issues. Older Series 60 models are particularly vulnerable due to idling and low pressure. Spun bearings are caused when bearings aren’t lubricated properly. They overheat and they’ll eventually seize. If you have an older Series 60 ensure that ... How to determine the ecm is bad and not functional on a DD60 Detroit 60 series no start diy no oil pressure signal no injector signalK = DDEC III or IV. Customer Designation. 28 = Buses 1991 and Later. 32 = Underground Mining. 40 = 1991 and Earlier. 60 = 1991 and Later On-Highway Trucks. Need help identifying Series 60 Detroit Diesel engines? Check out our online Detroit Diesel identification charts. We also supply Detroit Diesel parts with online ordering.3600 S. Noah Dr. Saxonburg, Pa. 16056. PittsburghPower.com, 724-360-4080. Share. Back to News. Even though the Detroit Diesel Series 60 was discontinued in 2011, it's still one of the most common engines for Class 8 trucks. Some may not know about the fascinating story behind these engines. At the onset of WWII General Motors created the GM ...Flash Code 41 - Too many SRS (Detroit 60 Series) Figure 1.1 - Too many SRS (EEC Information Display) Here the STEPS: 1). Connect DETROIT Engine DDEC using Detroit Diesel Diagnostic Link (DDDL v6.46). ... If the problem returns, the pulse wheel may be loose or bad or damaged. 6). Check TRS/ SRS Connectors ... Starting and Charging System (10 ...

K = DDEC III or IV. Customer Designation. 28 = Buses 1991 and Later. 32 = Underground Mining. 40 = 1991 and Earlier. 60 = 1991 and Later On-Highway Trucks. Need help identifying Series 60 Detroit Diesel engines? Check out our online Detroit Diesel identification charts. We also supply Detroit Diesel parts with online ordering.

I have a 06 century Detroit series 60 jake brake stopped wrking an now I'm seeingfault code for brake open but cnt seem to find any info on what that code means so I figure gotta be with jake brake any ideas on where to start ... Cruise control is also tied in but I assume it's working so probably not the problem ...I have a 60 series detroit, engine in a 98 Ford, with an intermitent no start. Cranks like it is out of fuel, small shot of ether and it will start. Runs perfect. Symtoms started as a cold weather problem, -20 C and colder. Now, even on a 25 C day, at times it will not start.The values correspond to the following options/information: Detroit 60 Series diesel specs, history, information, and torque curves. The Detroit 60 Series engine platform included an 11.1L, 12.7L, and 14L inline 6 cylinder diesel engine. 60 Series Detroits are widely popular in a number of on-highway and off-highway industries.Detroit Series 60 problems. Tags detroit series 60. Jump to Latest Follow ... Tends to idle rough when first starting when its cold even though its plugged in. Smoothens out after a minute or two depending how cold and we are talking a lot of -20 and colder mornings this past winter. Idles fairly fast, around 900 to 1000 rpms until its …Series 60 Air Temperature Sensor. On DDEC III/IV engines there is an Air Temperature Sensor (ATS) mounted to the bottom of the intake manifold. The ATS sends an electrical signal to the ECM indicating the inlet manifold temperature of the air entering the engine. The ECM uses this information to adjust gas flow, control air fuel ratio and in ...My detroit 60s 12.7 engine lost power. When I start driving truck drives normally and has power for first 5-20min then in a second I have no power. It takes like a minute to go from 0 to 60 and no big difference if empty or loaded. I can hear a turbo but the sound is weak even at higher rpms.Series 60 DDEC V Troubleshooting – Section 20.15 Optimized Idle Feature Does Not Function; Series 60 DDEC V Troubleshooting – Section 20.13 Fire Truck Pressure Governor Fault; Series 60 DDEC V Troubleshooting – Section 20.14 Troubleshooting Electronic Fire Commander; Series 60 DDEC V Troubleshooting – Section 20.12 …27 Apr 2019 ... ECM Detroit 60 Series how to fix the problem. ... Nice Cold Starting Up BIG DETROIT DIESEL ENGINES and SOUND ... DETROIT DIESEL 60 SERIES is the ...1. Effective with 6R56762, a manually operated fuel shutoff valve replaced a check valve. A PRO-CHEK ® valve may be installed at this location to remove air. ‪. 2. Effective with 6R8950, the ECM/EDU cooler unit was removed from all Series 60 engines used in on-highway applications. ‪. 3. Effective with unit 6R13060, a fuel system check ...

Menards garden gates

DDEC III/IV. Detroit Diesel Series 60 engines equipped with DDEC III or DDEC IV electronic control systems are identified by a “K” in the sixth position of the model number. Example: 6067GK60. Detroit Diesel Electronic Controlled Series 60 engines can be equipped with a variety of options designed to warn the operator of an engine malfunction.

1993 60 series Detroit diesel will start and run for only 30 seconds then shuts down. I have replaced the coolent level sensor. Submitted: 12 years ago ... i'm looking for some help on a 60 series detroit diesel engine with an intermintent no start problem. have checked trs and srs sensors. changed 1 injector that was leaking replaced 3 ...May 21, 2012 · have 60 series detriot with a starting problem , it loses prime have replaced lines shut offs , and check valve on return stiil bleeds of after a few hours of sitting. Could it be a injector bleeding off. It misses for a short time when it starts, and i have to hit it with starting fluid to get it going if it sits for a few hours. It has a 60 Series Detroit diesel engine that is hard to start and idles rough. If I can get it to start it runs very rough at below 500 RPM. After sometime the RPM will climb by itself to alittle of 500 RPMs. The engine shakes, knocks, and just sounds bad. It does smooth out when over 1000 RPM.Series 60 DDEC VI Troubleshooting – Section 4.9 Fuel Pump; Series 60 DDEC VI Troubleshooting – Section 4.8 Plugged Fuel Filter(S) Series 60 DDEC VI Troubleshooting – Section 4.6 Low Cranking Speed; Series 60 DDEC VI Troubleshooting – Section 4.7 Fuel Supply Valve; Series 60 DDEC VI Troubleshooting – Section 4.5 …3. Disconnect ventilation pipe from valve cover. 4. Remove engine cover. 5. Adjust Jake Brake (if applicable), injectors and valves following instructions in the Detroit Diesel service manual for series 60 engines. 6. Verify engine cover gasket and replace if necessary.Remove the turbocharger to charge-air-cooler (CAC) pipe. Pressurize the CAC inlet to 207 kPa (30 psi) using special tool TLZ00100 or equivalent. Using DDDL, monitor the boost pressure (psi). If the pressure is below 187 kPa (27 psi), visually inspect the CAC, hoses, and the delivery tube for leaks. Repair as necessary.The Detroit Diesel Series 60 is an inline-six 4 stroke diesel engine produced from 1987 to 2011. ... Starting in the late 1990s, ... The DDEC system allowed dealers and owners to troubleshoot problems with their engines, permitted changes to horsepower settings, and in some cases, alternative programs were able to be loaded into the computer. ...1. Connect Detroit Diesel Diagnostic Link (DDDL 7.0) to check the oil pressure. 2. Start and vary engine speed between 1800 - 2100 rpm. 3. Check DDDL 7.0 for oil pressure reading. [a] If DDDL 7.0 indicates oil pressure greater than or equal 241 kPa (35 psi) at 1800 rpm, shut down the engine and disconnect DDDL 7.0. Refer to section 6 to diagnoseAlfa Romeo's Giulia was named Motor Trend magazine's Car of the Year and did not disappoint at this year's Detroit auto show. Watch!...FCAU Alfa Romeo's Giulia was name...I have a Freightliner Century with a Detroit 12.7 s60. Recently the truck has become very hard to start and has lost power specially when going up hills. I have checked and cleaned the check valve on the filter and also the check valve behind the cylinder head. But still the same difficulty in starting, I have to use starting fluid all the time.I have a 60 series Detroit seems to start fine then shortly runs out of fuel dies sometimes I can crank it over and it - Answered by a verified Technician. ... Hey I have 1990 379 Pete with Detroit 60 series 12.7…my problem before was truck cranking and shutting of after maybe 30sec-2-3min.

3533 posts · Joined 2009. #5 · Dec 31, 2011. You need 195 RPM and an SRS signal to start, If you can get a reader, it will have a section for SRS and while cranking it must go to yes, and the speed must be above 195. Some codes set to 255 counts and the engine will not start untill they are fixed.Soluble Oils. Soluble oil additives are not approved for use in the Detroit Diesel Series 60 engine cooling systems. A small amount of oil adversely affects heat transfer. A 1.25% concentration of soluble oil increases the fire deck temperature 6%. A 2.50% concentration increases the fire deck temperature 15%.‪.Messages. 1. Reaction score. 0. Feb 6, 2021. #1. Hey guys! New to the forum! I've never posted to a forum before in my life but I'm at a stand still! I own a 08 Frightliner …Instagram:https://instagram. gem show san mateo ca Figure 3. Preventive Maintenance Service Items. Section 14.6.1. Lubricating Oil. Check the lubricating oil level with the engine stopped and the vehicle on level ground. If the engine has just been stopped and is warm, wait approximately ten minutes to allow the oil to drain back to the oil pan. 818 bowling houston series 60 – excessive crankcase pressure – defective air compressor To determine if a defective air compressor is causing excessive crankcase pressure, perform the following: 1.Perform a crankcase pressure test, refer to appropriate service manual, preventive maintenance chapter and record the test results.Hard start on a series 60. New injectors, head, bullgear, sensors, fuel system. Also tested with known good ECM and program. It was approximately 15C (... harbor freight port richey fl Remove dog house from floor pan, a 3/4 wrench, 15/16 wrench, and a 7/8 wrench are required. Ck valve is located on back of cyl head, it's a small stainless steel valve with a direction arrow, Detroit diesel logo and part number is 23516918 274399c. Oem part is around $250-$350. Aftermarket around $60. cybershift login doe I have a truck in my shop that I am struggling to figure out. It is a 09/2008 60 Series Detroit DDEC6 14.0 litre that came in for noticeable low power, EXCESSIVE blow by, and intermittent white smoke and missing when up to operating temp. Truck is a Freightliner Cascadia daycab that has 435,231 miles on it according to the speedometer … couponsky.net reviews 3533 posts · Joined 2009. #5 · Dec 31, 2011. You need 195 RPM and an SRS signal to start, If you can get a reader, it will have a section for SRS and while cranking it must go to yes, and the speed must be above 195. Some codes set to 255 counts and the engine will not start untill they are fixed. johnson hagglund funeral If exhaust gas leaks are detected, contact the Detroit Diesel Customer Support Center for further information (313–592–5800). Series 60 Service Manual - 6SE483 Generated on 10-13-200812.7 detroit backfire and choking blows raw feul out stacks. I've got an 98 379 with a Detroit 12.7 60 series. The issue I'm having is at lower rmp just barley rolling into the throttle it will start choking and slight backfire along with raw smelling grey smoke out the stacks. It only does it at lower rpm, speed you can pedal through it and it ... khalyla kuhn new relationship Series 60 - STARTING DIFFICULTY - ENGINE ROTATES - EXTENDED CRANK TIME. There are no fault codes present and the engine finally starts after an extended crank time. 4.13.1 Fuel Level/Leaks Check…3533 posts · Joined 2009. #5 · Dec 31, 2011. You need 195 RPM and an SRS signal to start, If you can get a reader, it will have a section for SRS and while cranking it must go to yes, and the speed must be above 195. Some codes set to 255 counts and the engine will not start untill they are fixed.About Press Copyright Contact us Creators Advertise Developers Terms Privacy Policy & Safety How YouTube works Test new features NFL Sunday Ticket Press Copyright ... kern jury duty Upon start up there is white smoke and a slight miss. (atmosphere temp not relevant here since warm or cold temps it makes white smoke) only for a minute or so and then it clears up. The miss also clears up. Stumped now, all the injectors have been replace even a reman ecm was put on still the same.Put in a new injector harness still the same I ... home outlet warren Hello all. Having a strange problem with my truck and I was hoping someone here would have a clue based on my particular symptoms. I have a 2004 Freightshaker with a 12.7 EGR Detroit 60 Series with just over 800k Mi. For the last several weeks if I turn the truck off for several hours I will... graduation card puns 40 is 8.7L (As the tag reflects.) 60 is about 14L (Below is the info I got while research I think either a Executive. or Signature Monaco) Series 60 Detroit Diesel 515 HP Engine with Allison® 4000 MH 6-Speed. World Transmission and Electronic Shifter; Torque: 1,650 lbs./ft.; Engine Displacement: 858" Cu. In.And I'm understanding that Detroit's own oil is bottled by delvac. A friend is running Schaefer's oil in his fresh engine, claims that his consumption dropped from running Chevron. But, it's not readily available on the road. My current engine has 800k on it, I service every 20k, running Chevron 15w-40, I use 2 gallons of oil between changes. amstar theater Advertisement In theory, rail guns are the perfect solution for short- and long-range firepower. In reality, they present several serious problems: Advertisement A coil gun (or Gau...The Detroit 60 Series earns much praise for its great balance of fuel economy, performance, and longevity. ... Read More Detroit 60 Series Diesel Common Problems. Other Diesel Engines. Ford 6.6 & 7.8 Diesel Engine Guide. By Jake Mayock November 23, 2022 December 30, 2023. The Ford 6.6 and 7.8 diesel engines are medium duty truck engines ...